Go Back   The 75 and ZT Owners Club Forums > The 75 and ZT Owners Club Forums > The 75 and ZT Owners Club General Forum
Register FAQ Image Gallery Members List Calendar Mark Forums Read
Notices

Reply
 
Thread Tools Display Modes
Old 6th October 2021, 11:36   #1
Rickshaw
Loves to post
 
Rover 75 Tourer, 2 X75 Saloon , MGTF Sunstorm

Join Date: Jan 2013
Location: Guildford
Posts: 379
Thanks: 497
Thanked 172 Times in 93 Posts
Thumbs down Gear Cables woes

At local breakers yesterday was a diesel 75 with totally loose gear stick - wobbled any way you like. I was told it was a low mileage car. SO , are gear cables something known to fail often or on rare occasions ? Appreciate views on this.
My second point is one of real anger - here is why. This car was immaculate , like new outside , inside , under the bonnet etc. Staff mentioned this and that it was low mileage with an engine that ran very smoothly. Why was it there I asked. Because the garage told the owner that the gear cables had broken and they could no longer be obtained - so owner scrapped it. A quick look on Google shows this as nonsense :-
• DMGRS sell new ones
• On EBay these - and associated parts - are available
I was rather angry yesterday. Perhaps the garage had more interest in selling a new car than bothering to look after their customers interests properly. The garage is somewhere in Sussex I think.
Wanted to vent my anger. Grrrrr !
Rickshaw is offline   Reply With Quote
Old 6th October 2021, 13:32   #2
DMGRS
Discount MG Rover Spares
 
DMGRS's Avatar
 
Rover 75 CDTi, 2x MG ZS180

Join Date: Jun 2011
Location: Hythe, Southampton
Posts: 11,317
Thanks: 456
Thanked 3,377 Times in 2,027 Posts
Default

Early gear cables are indeed hard to find - but the little-known secret seems to be that you can fit the later type if you swap the selector mechanism (the bit under the knob itself) too.

Not a hard job, and we now recommend owners of early cars find a selector mechanism from a breaker, then complement with a set of our cables.
__________________



Your trusted MG Rover specialist!
Tel: 02380 001133 / Email: [email protected]

We now have a 'chat' function on our site for even quicker replies. Give it a try!

Remember - discount code FORUM5 for 5% off
DMGRS is offline   Reply With Quote
Old 6th October 2021, 15:58   #3
macafee2
This is my second home
 
Rover 75 Saloon & Tourer

Join Date: Sep 2012
Location: Lincoln
Posts: 14,890
Thanks: 1,630
Thanked 3,032 Times in 2,181 Posts
Default

At the gearbox end of the cables is a spring clip, these can snap so if there, take them as I have a feeling they are no longer available as a separate item.

macafee2
macafee2 is offline   Reply With Quote
Old 6th October 2021, 20:21   #4
Rickshaw
Loves to post
 
Rover 75 Tourer, 2 X75 Saloon , MGTF Sunstorm

Join Date: Jan 2013
Location: Guildford
Posts: 379
Thanks: 497
Thanked 172 Times in 93 Posts
Question Re DMGRS observations

Advice re contacting a breaker to acquire updated version of the selector unit BUT can anyone (DMGRS?) suggest a date or car serial number onwards frm when the updated version will be found. My cars are from 2002 and I would guess this makes them 'old' selector unit?
Observations most welcome
Rickshaw is offline   Reply With Quote
Old 7th October 2021, 11:06   #5
Rickshaw
Loves to post
 
Rover 75 Tourer, 2 X75 Saloon , MGTF Sunstorm

Join Date: Jan 2013
Location: Guildford
Posts: 379
Thanks: 497
Thanked 172 Times in 93 Posts
Question Is BLINK still around ?

Excellent thread in Nov 2020 by Blink , who had broken Gear cable and sought to replace . He purchased cables from EBay after taking advice from Daveluck who had fitted them in 2016 with success. Blink's thread does not seem to end with him reporting that he did manage to install and his car now working fine.
Does anyone know??
I tried to PM Blink but system says his PM inbox is full and cannot accept any more input!
His thread is , however , very informative.
Rickshaw is offline   Reply With Quote
Old 7th October 2021, 12:58   #6
planenut
Regional Secretary
 
planenut's Avatar
 
Rover 1.8T Tourer

Join Date: May 2007
Location: Heathrow
Posts: 6,935
Thanks: 1,551
Thanked 2,036 Times in 1,264 Posts
Default

To replace the cables is not straightforward but I'm no mechanic but succeeded. The information on this site proved invaluable, and I got a good set from eBay.

Garages will be pursuing profit which is more than cables cost.

In fact, the one I did the work on was sold because of the cable fault.

Last edited by planenut; 7th October 2021 at 13:00..
planenut is offline   Reply With Quote
Old 7th October 2021, 13:06   #7
Rickshaw
Loves to post
 
Rover 75 Tourer, 2 X75 Saloon , MGTF Sunstorm

Join Date: Jan 2013
Location: Guildford
Posts: 379
Thanks: 497
Thanked 172 Times in 93 Posts
Smile Car year ?

Thanks for that and another confirmation re the EBay supply. Just like to know what year your car is ?
All the best.
Rickshaw is offline   Reply With Quote
Old 7th October 2021, 22:35   #8
X10Rich
Loves to post
 
X10Rich's Avatar
 
MG ZT+ 190

Join Date: Apr 2009
Location: Chipping Norton
Posts: 391
Thanks: 6
Thanked 26 Times in 22 Posts
Default

I think the change occured at VIN 4D307061
X10Rich is offline   Reply With Quote
Old 8th October 2021, 06:52   #9
planenut
Regional Secretary
 
planenut's Avatar
 
Rover 1.8T Tourer

Join Date: May 2007
Location: Heathrow
Posts: 6,935
Thanks: 1,551
Thanked 2,036 Times in 1,264 Posts
Default

Quote:
Originally Posted by Rickshaw View Post
Thanks for that and another confirmation re the EBay supply. Just like to know what year your car is ?
All the best.

54 plate was the one I did that job on.
planenut is offline   Reply With Quote
Old 8th October 2021, 17:13   #10
Rickshaw
Loves to post
 
Rover 75 Tourer, 2 X75 Saloon , MGTF Sunstorm

Join Date: Jan 2013
Location: Guildford
Posts: 379
Thanks: 497
Thanked 172 Times in 93 Posts
Question Gear selections 2.0 versus 1.8

Thanks for the two responses above and another query to clear another fuzzy aspect :-
Is there a difference in the Gear selection units and Cables between a 2 litre and 1.8 litre model. Eg a Petrol or Diesel 2.0 and a diesel or petrol 1.8. ?
Where does a 2.5litre sit in all this - same units as a 2.0 ?

I can't see any reason for a difference - but one gets used to being surprised.

Hopefully , the info in this thread will be of benefit to others in the future.

After thought - anyone any idea when VIN 4D307061 was -ish?
Follow up - after examining an excellent earlier thread on this club site about VIN numbers interpretation I believe the '4D' in the VIN above refers to 2004 and D = manufactured in Longbridge. This impliesthat some time in 2004 the Gear Selection Mechanism was changed . So cars upto and including 2003 are the same 'old' mechanism and after some time in 2004 it was changed . Facelift time ?

Last edited by Rickshaw; 9th October 2021 at 19:20.. Reason: After thought about a 2.5 l too plus VIN date
Rickshaw is offline   Reply With Quote
Reply

Thread Tools
Display Modes

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off

Forum Jump


All times are GMT. The time now is 22:31.


Powered by vBulletin® Version 3.8.11
Copyright ©2000 - 2024, vBulletin Solutions Inc.
Copyright © 2006-2023, The Rover 75 & MG ZT Owners Club Ltd